diagnostyka gem - moduł główny.pdf

(970 KB) Pobierz
<!DOCTYPE html PUBLIC "-//W3C//DTD HTML 4.01//EN" "http://www.w3.org/TR/html4/strict.dtd">
Strona 1 z 21
Multifunction Electronic Modules - Generic Electronic Module (GEM)
Mondeo 2007.5 (02/2007-)
Print
Diagnosis and Testing
Special Tool( s )
Terminal Probe Kit
418-S035
General Equipment
Digital multimeter
Integrated Diagnostic System (IDS)
Inspection and Testing
1. 1. VERIFY the customer concern.
2. 2. Visually CHECK for any obvious mechanical or electrical damage.
NOTE: Ensure correct locking of wiring harness connector.
Visual Inspection
Electrical
Fuses.
Wiring harness.
Electrical connectors.
3. 3. RECTIFY any obvious causes for a concern found during the visual inspection before performing any further tests. CHECK the operation of the
system.
4. 4. If the concern persists after the visual inspection, PERFORM a fault diagnosis with IDS, RECTIFY any displayed faults in accordance with the
displayed fault description and then DELETE the displayed fault(s). CHECK the operation of the system.
5. 5. For vehicles with no stored faults, PROCEED in accordance with the Symptom Chart for the corresponding concern.
6. 6. Following checking or elimination of the fault and after completion of operations, the fault memories of all vehicle modules must be READ OUT and
any stored faults must be DELETED. READ OUT all fault memories again following a road test.
Diagnostic Trouble Code (DTC) Table
CAUTION: Before replacing the GEM in the event of a GEM malfunction, PERFORM a "hardware reset" after WORKING THROUGH the relevant DTC. To
do this, disconnect connector C1BP02-G from the GEM and reconnect it. CHECK the operation of the system. If the malfunction persists, make sure that
the latest release of the software is loaded in IDS and that the correct variant of the GEM is installed. CONFIGURE GEM again using IDS. If the fault
occurs again, RENEW THE GEM.
DTC
Description
Action
B1108-77
Status - faulty driver's door central locking
motor.
See IDS.
B1109-77
Status - faulty front passenger door central
l o cking motor.
See IDS.
B110A-77
Status - faulty central locking motor - driver's
s ide rear door.
See IDS.
B110B-77
Status - faulty central locking motor - passenger
s ide rear door.
See IDS.
B10EB-77
Status - faulty driver's door double locking
motor.
See IDS
B10EC-77
Status - faulty front passenger door double
l o cking motor.
See IDS
B10ED-77
Status - faulty double locking motor - driver's
s ide rear door.
See IDS
B10EE-77
Status - faulty double locking motor - passenger
s ide rear door.
See IDS
B10E1-12, B10E1-14, B10E2-12,
B10E2-14, B10E3-12, B10E3-14
Circuits of rear central locking relay faulty.
See IDS.
B10EF-12
Circuit of sliding sun roof module faulty (short to
v oltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B10EF-14
Circuit of sliding sun roof module faulty (short to
g round or open circuit).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B113D-14
Circuit of sliding sun roof module "general close
f unction" faulty (short to ground or open circuit).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B113D-12
Circuit of sliding sun roof module "general close
f unction" faulty (short to voltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B10A2-02, B10A2-11, B10A2-15 Power/signal circuits of crash sensor faulty.
REFER to: Air Bag Supplemental Restraint System (SRS) (501-20B
S upplemental Restraint System, Diagnosis and Testing).
B10A2-00
Faulty signal from crash sensor
REFER to: Air Bag Supplemental Restraint System (SRS) (501-20B
S upplemental Restraint System, Diagnosis and Testing).
U0452-00, U0452-62
Fuel shut-off signal from safety restraints
module faulty.
REFER to: Air Bag Supplemental Restraint System (SRS) (501-20B
S upplemental Restraint System, Diagnosis and Testing).
C1A41-21, C1A41-22
Signal circuits of clutch pedal position switch
f aulty.
See IDS.
B1029-21, B1029-22
Signal circuits of accelerator pedal position
s ensor faulty.
See IDS.
C1108-01, C1108-12
Circuits for accelerator pedal position sensor and
clutch pedal position switch faulty (short to
g round or to voltage supply)
See IDS.
B10AF-14
Circuit of cooling fan relay faulty (short to
ground or open circuit).
REFER to: Engine Cooling (303-03B Engine Cooling - 2.0L Duratec-HE
(107kW/145PS) - MI4/2.0L Duratec-HE Flex Fuel (107kW/145PS) -
MI4/2.3L Duratec-HE (118kW/160PS) - MI4, Diagnosis and Testing).
B10AF-12
Circuit of battery protection relay faulty (short to
voltage).
REFER to: Engine Cooling (303-03B Engine Cooling - 2.0L Duratec-HE
(107kW/145PS) - MI4/2.0L Duratec-HE Flex Fuel (107kW/145PS) -
MI4/2.3L Duratec-HE (118kW/160PS) - MI4, Diagnosis and Testing).
B1D06-13
Circuit of left-hand turn signal lamp faulty (open
c ircuit).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B1D06-11
Circuit of left-hand turn signal lamps faulty
( short to ground).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=1449&proc-uid=G927143&gui...
2012-08-11
873831852.550.png 873831852.661.png 873831852.746.png 873831852.757.png 873831852.001.png 873831852.012.png 873831852.022.png 873831852.033.png 873831852.044.png 873831852.055.png 873831852.066.png 873831852.077.png 873831852.088.png 873831852.099.png 873831852.110.png 873831852.121.png 873831852.132.png 873831852.143.png 873831852.154.png 873831852.165.png 873831852.176.png 873831852.187.png 873831852.198.png 873831852.209.png 873831852.220.png 873831852.231.png 873831852.242.png 873831852.253.png 873831852.264.png 873831852.275.png 873831852.286.png 873831852.297.png 873831852.308.png 873831852.319.png 873831852.330.png 873831852.341.png 873831852.352.png 873831852.363.png 873831852.374.png 873831852.385.png 873831852.396.png 873831852.407.png 873831852.418.png 873831852.429.png 873831852.440.png 873831852.451.png 873831852.462.png 873831852.473.png 873831852.484.png 873831852.495.png 873831852.506.png 873831852.517.png 873831852.528.png 873831852.539.png 873831852.551.png 873831852.562.png 873831852.573.png 873831852.584.png 873831852.595.png 873831852.606.png 873831852.617.png 873831852.628.png 873831852.639.png 873831852.650.png 873831852.662.png 873831852.673.png 873831852.684.png 873831852.695.png 873831852.706.png 873831852.717.png 873831852.728.png 873831852.739.png 873831852.744.png 873831852.745.png 873831852.747.png 873831852.748.png 873831852.749.png 873831852.750.png 873831852.751.png 873831852.752.png 873831852.753.png 873831852.754.png 873831852.755.png 873831852.756.png 873831852.758.png 873831852.759.png 873831852.760.png 873831852.761.png 873831852.762.png 873831852.763.png 873831852.764.png 873831852.765.png 873831852.766.png 873831852.767.png 873831852.002.png 873831852.003.png 873831852.004.png 873831852.005.png 873831852.006.png 873831852.007.png 873831852.008.png 873831852.009.png 873831852.010.png 873831852.011.png 873831852.013.png 873831852.014.png 873831852.015.png 873831852.016.png 873831852.017.png 873831852.018.png 873831852.019.png 873831852.020.png
 
Strona 2 z 21
B11D3-11
Circuit of left-hand side turn signal lamp faulty
( short to ground).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B11D3-13
Circuit of left-hand side turn signal lamp faulty
( open circuit).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B1D07-11
Circuit of right-hand turn signal lamps faulty
( short to ground).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B1D07-13
Circuit of right-hand turn signal lamps faulty
( open circuit).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B11CB-11
Circuit of right-hand side turn signal lamp faulty
( short to ground).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B11CB-13
Circuit of right-hand side turn signal lamp faulty
( open circuit).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B113C-11
Circuit of light for hazard warning switch faulty
( short to ground).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B113C-15
Circuit of light for hazard warning switch faulty
( short to voltage or open circuit).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
B1D35-24
Circuit of hazard warning switch faulty (switch
c ontinuously active).
REFER to: Turn Signal, Cornering and Hazard Lamps (417-01 Exterior
L ighting, Diagnosis and Testing).
U2010-11
Circuit of interior light faulty (short to ground). REFER to: Interior Lighting (417-02 Interior Lighting, Diagnosis and
T esting).
U2010-15
Circuit of interior light faulty (short to voltage) REFER to: Interior Lighting (417-02 Interior Lighting, Diagnosis and
T esting).
B1D13-12, B1D1A-12
Circuit of interior light switch-off delay faulty
( short to voltage)
REFER to: Interior Lighting (417-02 Interior Lighting, Diagnosis and
T esting).
B1130-07
L ight switch unit, component fault.
R EFER to: Headlamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1D00-11
Circuit of left-hand headlamp faulty (short to
g round).
REFER to: Headlamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1D01-11
Circuit of right-hand headlamp faulty (short to
g round).
REFER to: Headlamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1D00-13
Circuit of left-hand headlamp faulty (open
c ircuit).
REFER to: Headlamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1D01-13
Circuit of right-hand headlamp faulty (open
c ircuit).
REFER to: Headlamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1098-11
Circuit of left-hand marker lamp faulty (short to
g round).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B1098-13
Circuit of left-hand marker lamp faulty (open
c ircuit).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B1099-11
Circuit of right-hand marker lamp faulty (short
t o ground).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B1099-13
Circuit of right-hand marker lamp faulty (open
c ircuit).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B109B-13
Circuit of license plate lamps faulty (open
c ircuit).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B109B-11
Circuit of license plate lamps faulty (short to
g round).
REFER to: Parking, Rear and License Plate Lamps (417-01 Exterior Lighting,
D iagnosis and Testing).
B1A79-13
C ircuit of rear fog lamps faulty (open circuit). R EFER to: Fog Lamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1A79-11
Circuit of rear fog lamps faulty (short to
g round).
REFER to: Fog Lamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1115-11
Circuit of high-mounted stop lamp faulty (short
t o ground).
REFER to: Stoplamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1115-13
Circuit of high-mounted stop lamp faulty (open
c ircuit).
REFER to: Stoplamps (417-01 Exterior Lighting, Diagnosis and Testing).
B1095-12
Circuit of windshield washer system relay
( on/off) faulty (short to voltage supply).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1095-14
Circuit of windshield washer system relay
( on/off) faulty (short to ground or open circuit).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1096-12
Circuit of windshield washer system relay
( fast/slow) faulty (short to voltage supply).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1096-14
Circuit of windshield washer system relay
(fast/slow) faulty (short to ground or open
c ircuit).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
and Testing).
B1D39-14
Circuit of rear wiper relay faulty (short to
v oltage supply).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1D39-12
Circuit of rear wiper relay faulty (short to ground
o r open circuit).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1C82-12
Circuit of headlamp washer relay faulty (short to
v oltage)
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B1C82-14
Circuit of headlamp washer system relay faulty
( short to ground or open circuit).
REFER to: Wipers and Washers (501-16 Wipers and Washers, Diagnosis
a nd Testing).
B10AD-09
Rain sensor/light sensor, component fault.
REFER to:
Autolamps (417-01 Exterior Lighting, Diagnosis and Testing),
Wipers and Washers (501-16 Wipers and Washers, Diagnosis and
Testing).
B10AD-04
Internal circuit of rain sensor/light sensor faulty. REFER to:
Autolamps (417-01 Exterior Lighting, Diagnosis and Testing),
Wipers and Washers (501-16 Wipers and Washers, Diagnosis and
Testing).
B1133-11
Circuit of heated windshield LED faulty (short to
g round).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B1133-12
Circuit of heated windshield LED faulty (short to
v oltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B1097-12
Circuit of heated windshield relay faulty (short to
v oltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B1097-14
Circuit of heated windshield relay faulty (short to
g round).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B112D-11
Circuit of heated rear window LED faulty (short
t o ground).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B112D-12
Circuit of heated rear window LED faulty (short
t o voltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B1C84-14
Circuit of heated rear window relay faulty (short
t o ground or open circuit).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
B1C84-12
Circuit of heated rear window relay faulty (short
t o voltage).
REFER to: Glass, Frames and Mechanisms (501-11 Glass, Frames and
Mechanisms, Diagnosis and Testing).
U2101-00, B1A84-41
Central module configuration faulty.
Make certain that the latest release of the software is loaded in IDS and
that the correct variant of the GEM is installed.
CONFIGURE GEM again using IDS. If the fault occurs again, RENEW THE
GEM.
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=1449&proc-uid=G927143&gui...
2012-08-11
873831852.021.png 873831852.023.png 873831852.024.png 873831852.025.png 873831852.026.png 873831852.027.png 873831852.028.png 873831852.029.png 873831852.030.png 873831852.031.png 873831852.032.png 873831852.034.png 873831852.035.png 873831852.036.png 873831852.037.png 873831852.038.png 873831852.039.png 873831852.040.png 873831852.041.png 873831852.042.png 873831852.043.png 873831852.045.png 873831852.046.png 873831852.047.png 873831852.048.png 873831852.049.png 873831852.050.png 873831852.051.png 873831852.052.png 873831852.053.png 873831852.054.png 873831852.056.png 873831852.057.png 873831852.058.png 873831852.059.png 873831852.060.png 873831852.061.png 873831852.062.png 873831852.063.png 873831852.064.png 873831852.065.png 873831852.067.png 873831852.068.png 873831852.069.png 873831852.070.png 873831852.071.png 873831852.072.png 873831852.073.png 873831852.074.png 873831852.075.png 873831852.076.png 873831852.078.png 873831852.079.png 873831852.080.png 873831852.081.png 873831852.082.png 873831852.083.png 873831852.084.png 873831852.085.png 873831852.086.png 873831852.087.png 873831852.089.png 873831852.090.png 873831852.091.png 873831852.092.png 873831852.093.png 873831852.094.png 873831852.095.png 873831852.096.png 873831852.097.png 873831852.098.png 873831852.100.png 873831852.101.png 873831852.102.png 873831852.103.png 873831852.104.png 873831852.105.png 873831852.106.png 873831852.107.png 873831852.108.png 873831852.109.png 873831852.111.png 873831852.112.png 873831852.113.png 873831852.114.png 873831852.115.png 873831852.116.png 873831852.117.png 873831852.118.png 873831852.119.png 873831852.120.png 873831852.122.png 873831852.123.png 873831852.124.png 873831852.125.png 873831852.126.png 873831852.127.png 873831852.128.png 873831852.129.png 873831852.130.png 873831852.131.png 873831852.133.png 873831852.134.png 873831852.135.png 873831852.136.png 873831852.137.png 873831852.138.png 873831852.139.png 873831852.140.png 873831852.141.png 873831852.142.png 873831852.144.png 873831852.145.png 873831852.146.png 873831852.147.png 873831852.148.png 873831852.149.png 873831852.150.png 873831852.151.png 873831852.152.png 873831852.153.png 873831852.155.png 873831852.156.png 873831852.157.png 873831852.158.png 873831852.159.png 873831852.160.png 873831852.161.png 873831852.162.png 873831852.163.png 873831852.164.png 873831852.166.png 873831852.167.png 873831852.168.png 873831852.169.png 873831852.170.png 873831852.171.png 873831852.172.png 873831852.173.png 873831852.174.png 873831852.175.png 873831852.177.png 873831852.178.png 873831852.179.png 873831852.180.png 873831852.181.png 873831852.182.png 873831852.183.png 873831852.184.png 873831852.185.png 873831852.186.png 873831852.188.png 873831852.189.png 873831852.190.png 873831852.191.png 873831852.192.png
Strona 3 z 21
U2018-41, U2017-41, U3000-51,
B1A99-04
Module configuration faulty.
Make certain that the latest release of the software is loaded in IDS and
that the correct variant of the GEM is installed.
CONFIGURE GEM again using IDS. If the fault occurs again, RENEW THE
GEM.
P0604-00, P0605-00, P062F-00 Internal control unit fault.
Make certain that the latest release of the software is loaded in IDS and
that the correct variant of the GEM is installed.
CONFIGURE GEM again using IDS. If the fault occurs again, RENEW THE
GEM.
U3008-01
GEM circuit faulty (open circuit in electronics
g round).
GO to Pinpoint Test B.
B10A5-12
Circuit of anti-theft alarm horn faulty (short to
v oltage supply).
See IDS.
B10A5-14
Circuit of anti-theft alarm horn faulty (short to
g round or open circuit).
See IDS.
B1D17-96, B1D17-00
Internal circuit of the battery backed horn for
t he anti-theft system (BBS) faulty.
See IDS.
B1D18-96
I nternal fault in interior monitoring sensor.
S ee IDS
B10D7-81, B10D5-94, B10DA-51,
B10D8-00, B10D7-51, B10D7-05,
B10D7-94, U0515-87, B10D7-87
PATS system fault.
REFER to: Anti-Theft - Passive (419-01B Anti-Theft - Passive, Diagnosis and
Testing).
B11CC-51
PATS transponder not programmed.
REFER to: Anti-Theft - Passive (419-01B Anti-Theft - Passive, Diagnosis and
T esting).
B112A-12
Circuit of auxiliary ignition relay in the rear
junction box (RJB) faulty (short to voltage
s upply).
GO to Pinpoint Test C.
U3003-16, U3003-17
C harging system at fault.
S ee IDS.
B11BC-15
Circuit of ignition relay faulty (short to voltage
supply or open circuit).
CLEAR the fault memory.
If the fault occurs after READING OUT the fault memory again, RENEW the
g eneric electronic module (GEM).
B11BC-11
Ignition relay circuit faulty (short to ground). CLEAR the fault memory.
If the fault occurs after READING OUT the fault memory again, RENEW the
g eneric electronic module (GEM).
B1C55-12
Circuit of signal horn relay faulty (short to
v oltage).
See IDS.
B1C55-14
Circuit of signal horn relay faulty (short to
g round or open circuit).
See IDS.
P0462-00
Circuit of fuel level indicator sensor faulty (short
t o ground).
See IDS.
P0460-15
Circuit of fuel level indicator sensor faulty (short
t o voltage or open circuit).
See IDS.
B100A-11
Circuit of fuel pump relay faulty (short to
ground).
REFER to: (310-00A Fuel System - General Information)
Fuel System - 1.6L Duratec-16V Ti-VCT (Sigma)/2.0L Duratec-HE
(MI4)/2.3L Duratec-HE (MI4)/2.5L Duratec (VI5) (Diagnosis and
Testing),
Fuel System - 1.8L Duratorq-TDCi (Lynx) Diesel/2.0L Duratorq-TDCi
(DW) Diesel (Diagnosis and Testing).
B100A-15
Circuit of fuel pump relay faulty (short to voltage
or open circuit).
REFER to: (310-00A Fuel System - General Information)
Fuel System - 1.6L Duratec-16V Ti-VCT (Sigma)/2.0L Duratec-HE
(MI4)/2.3L Duratec-HE (MI4)/2.5L Duratec (VI5) (Diagnosis and
Testing),
Fuel System - 1.8L Duratorq-TDCi (Lynx) Diesel/2.0L Duratorq-TDCi
(DW) Diesel (Diagnosis and Testing).
B10C0-14, B10C0-12
Fuel pump circuits faulty.
REFER to: (310-00A Fuel System - General Information)
Fuel System - 1.6L Duratec-16V Ti-VCT (Sigma)/2.0L Duratec-HE
(MI4)/2.3L Duratec-HE (MI4)/2.5L Duratec (VI5) (Diagnosis and
Testing),
Fuel System - 1.8L Duratorq-TDCi (Lynx) Diesel/2.0L Duratorq-TDCi
(DW) Diesel (Diagnosis and Testing).
B1182-51
Tire pressure monitoring module configuration
faulty.
Make sure that the vehicle is in normal mode.
CLEAR the fault memory.
C ARRY OUT a road test.
C1D21-05
S ignal of tire pressure warning sensors faulty. GO to Pinpoint Test H.
C1D18-00
Not possible to locate the tire pressure warning
sensors (signal from at least two tire pressure
monitoring antennae faulty).
GO to Pinpoint Test I.
C1A56-93
Front left tire pressure warning sensor
inoperative.
The diagnostic trouble code may occur if a tire pressure warning sensor is
missing (e.g. if the wheel has been changed).
CHECK whether the tire pressure warning sensor is fitted.
If a tire pressure warning sensor is fitted, RENEW the tire pressure warning
s ensor. CHECK the operation of the system.
C1A56-16
Signal of front left tire pressure warning sensor
f aulty (battery discharged).
RENEW the tire pressure warning sensor.
C1A56-86
Signal of front left tire pressure warning sensor
faulty.
CLEAR the fault memory.
CARRY OUT a road test.
If the fault occurs after READING OUT the fault memory again, RENEW the
t ire pressure warning sensor. CHECK the operation of the system.
C1A58-93
Front right tire pressure warning sensor
inoperative.
The diagnostic trouble code may occur if a tire pressure warning sensor is
missing (e.g. if the wheel has been changed).
CHECK whether the tire pressure warning sensor is fitted.
If a tire pressure warning sensor is fitted, RENEW the tire pressure warning
s ensor. CHECK the operation of the system.
C1A58-16
Signal of front right tire pressure warning sensor
f aulty (battery discharged).
RENEW the tire pressure warning sensor.
C1A58-86
Signal of front right tire pressure warning sensor
faulty.
CLEAR the fault memory.
CARRY OUT a road test.
If the fault occurs after READING OUT the fault memory again, RENEW the
t ire pressure warning sensor. CHECK the operation of the system.
C1A62-93
Rear right tire pressure warning sensor
inoperative.
The diagnostic trouble code may occur if a tire pressure warning sensor is
missing (e.g. if the wheel has been changed).
CHECK whether the tire pressure warning sensor is fitted.
If a tire pressure warning sensor is fitted, RENEW the tire pressure warning
s ensor. CHECK the operation of the system.
C1A62-16
Signal of rear right tire pressure warning sensor
f aulty (battery discharged).
RENEW the tire pressure warning sensor.
C1A62-86
Signal of rear right tire pressure warning sensor
faulty.
CLEAR the fault memory.
CARRY OUT a road test.
If the fault occurs after READING OUT the fault memory again, RENEW the
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=1449&proc-uid=G927143&gui...
2012-08-11
873831852.193.png 873831852.194.png 873831852.195.png 873831852.196.png 873831852.197.png 873831852.199.png 873831852.200.png 873831852.201.png 873831852.202.png 873831852.203.png 873831852.204.png 873831852.205.png 873831852.206.png 873831852.207.png 873831852.208.png 873831852.210.png 873831852.211.png 873831852.212.png 873831852.213.png 873831852.214.png 873831852.215.png 873831852.216.png 873831852.217.png 873831852.218.png 873831852.219.png 873831852.221.png 873831852.222.png 873831852.223.png 873831852.224.png 873831852.225.png 873831852.226.png 873831852.227.png 873831852.228.png 873831852.229.png 873831852.230.png 873831852.232.png 873831852.233.png 873831852.234.png 873831852.235.png 873831852.236.png 873831852.237.png 873831852.238.png 873831852.239.png 873831852.240.png 873831852.241.png 873831852.243.png 873831852.244.png 873831852.245.png 873831852.246.png 873831852.247.png 873831852.248.png 873831852.249.png 873831852.250.png 873831852.251.png 873831852.252.png 873831852.254.png 873831852.255.png 873831852.256.png 873831852.257.png 873831852.258.png 873831852.259.png 873831852.260.png 873831852.261.png 873831852.262.png 873831852.263.png 873831852.265.png 873831852.266.png 873831852.267.png 873831852.268.png 873831852.269.png 873831852.270.png 873831852.271.png 873831852.272.png 873831852.273.png 873831852.274.png 873831852.276.png 873831852.277.png 873831852.278.png 873831852.279.png 873831852.280.png 873831852.281.png 873831852.282.png 873831852.283.png 873831852.284.png 873831852.285.png 873831852.287.png 873831852.288.png 873831852.289.png 873831852.290.png 873831852.291.png 873831852.292.png 873831852.293.png 873831852.294.png 873831852.295.png 873831852.296.png 873831852.298.png 873831852.299.png 873831852.300.png 873831852.301.png 873831852.302.png 873831852.303.png 873831852.304.png 873831852.305.png 873831852.306.png 873831852.307.png 873831852.309.png 873831852.310.png 873831852.311.png 873831852.312.png 873831852.313.png 873831852.314.png 873831852.315.png 873831852.316.png 873831852.317.png 873831852.318.png 873831852.320.png 873831852.321.png 873831852.322.png 873831852.323.png 873831852.324.png 873831852.325.png 873831852.326.png 873831852.327.png 873831852.328.png 873831852.329.png 873831852.331.png 873831852.332.png 873831852.333.png 873831852.334.png 873831852.335.png 873831852.336.png 873831852.337.png 873831852.338.png 873831852.339.png 873831852.340.png 873831852.342.png 873831852.343.png 873831852.344.png 873831852.345.png 873831852.346.png 873831852.347.png 873831852.348.png 873831852.349.png 873831852.350.png 873831852.351.png 873831852.353.png 873831852.354.png 873831852.355.png 873831852.356.png 873831852.357.png 873831852.358.png 873831852.359.png 873831852.360.png 873831852.361.png 873831852.362.png 873831852.364.png 873831852.365.png 873831852.366.png 873831852.367.png 873831852.368.png 873831852.369.png 873831852.370.png
Strona 4 z 21
t ire pressure warning sensor. CHECK the operation of the system.
C1A60-93
Rear left tire pressure warning sensor
inoperative.
The diagnostic trouble code may occur if a tire pressure warning sensor is
missing (e.g. if the wheel has been changed).
CHECK whether the tire pressure warning sensor is fitted.
If a tire pressure warning sensor is fitted, RENEW the tire pressure warning
s ensor. CHECK the operation of the system.
C1A60-16
Signal of rear left tire pressure warning sensor
f aulty (battery discharged).
RENEW the tire pressure warning sensor.
C1A60-86
Signal of rear left tire pressure warning sensor
faulty.
CLEAR the fault memory.
CARRY OUT a road test.
If the fault occurs after READING OUT the fault memory again, RENEW the
t ire pressure warning sensor. CHECK the operation of the system.
C1A57-11
Circuit of front left tire pressure monitoring
a ntenna faulty (short to ground).
GO to Pinpoint Test J.
C1A57-12
Circuit of front left tire pressure monitoring
a ntenna faulty (short to voltage supply).
GO to Pinpoint Test K.
C1A57-13
Circuit of front left tire pressure monitoring
a ntenna faulty (open circuit).
GO to Pinpoint Test L.
C1A59-11
Circuit of front right tire pressure monitoring
a ntenna faulty (short to ground).
GO to Pinpoint Test M.
C1A59-12
Circuit of front right tire pressure monitoring
a ntenna faulty (short to voltage supply).
GO to Pinpoint Test N.
C1A59-13
Circuit of front right tire pressure monitoring
a ntenna faulty (open circuit).
GO to Pinpoint Test O.
C1A61-11
Circuit of rear left tire pressure monitoring
a ntenna faulty (short to ground).
GO to Pinpoint Test P.
C1A61-12
Circuit of rear left tire pressure monitoring
a ntenna faulty (short to voltage supply).
GO to Pinpoint Test Q.
C1A61-13
Circuit of rear left tire pressure monitoring
a ntenna faulty (open circuit).
GO to Pinpoint Test R.
C1A63-11
Circuit of rear right tire pressure monitoring
a ntenna faulty (short to ground).
GO to Pinpoint Test S.
C1A63-12
Circuit of rear right tire pressure monitoring
a ntenna faulty (short to voltage supply).
GO to Pinpoint Test T.
C1A63-13
Circuit of rear right tire pressure monitoring
a ntenna faulty (open circuit).
GO to Pinpoint Test U.
U201F-87
No communication possible with the remote
control/tire pressure monitoring receiver
module.
GO to Pinpoint Test V.
U201F-04
Internal fault in remote control/tire pressure
monitoring receiver module.
See IDS.
B1D21-62
R emote control not synchronized.
R E-PROGRAM the remote controls.
B1B71-11
Circuit of evaporator temperature sensor faulty
( short to ground).
REFER to: Climate Control System (412-00 Climate Control System -
General Information, Diagnosis and Testing).
B1B71-13
Circuit of evaporator temperature sensor faulty
( open circuit).
REFER to: Climate Control System (412-00 Climate Control System -
General Information, Diagnosis and Testing).
B10EA-12
Circuit of electric booster heater faulty (short to
v oltage)
REFER to: Climate Control System (412-00 Climate Control System -
General Information, Diagnosis and Testing).
B10EA-14
Circuit of electric booster heater faulty (short to
g round or open circuit).
REFER to: Climate Control System (412-00 Climate Control System -
General Information, Diagnosis and Testing).
B112B-07
S teering wheel module switch faulty.
S ee IDS.
B10AC-95, B10AC-87, B10AC-86 S peed control system, system fault.
S ee IDS.
C2003-49, C1D22-49
I nternal fault in speed control system switches. S ee IDS.
U2108-53, U2107-53
A daptive speed control system, system fault. S ee IDS.
U0401-00
Invalid data from PCM to distance warning
s ystem module.
See IDS.
U0405-00
Invalid data from distance warning system radar
u nit to distance warning system module.
See IDS.
U2001-87
Missing signals from anti-lock braking system
module, PCM, distance warning system radar
u nit.
See IDS.
U0515-00
Feedback from the keyless vehicle module
f aulty.
See IDS.
B10E5-11
PCM wake-up signal from GEM faulty (short to
g round).
- Vehicles with 2.5L Duratec-ST (VI5) engine: GO to Pinpoint Test D.
- Vehicles with 2.2L Duratorq-TDCi (DW) engine: GO to Pinpoint Test E.
B10E5-15
PCM wake-up signal from GEM faulty (short to
v oltage supply or open circuit).
- Vehicles with 2.5L Duratec-ST (VI5) engine: GO to Pinpoint Test F.
- Vehicles with 2.2L Duratorq-TDCi (DW) engine: GO to Pinpoint Test G.
U0181-00
No communications possible with the headlamp
l e veling module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0155-00
No communication with the electronic instrument
c luster.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0121-00
No communication with the anti-block brake
s ystem module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0100-00
No communication with the powertrain control
module (PCM).
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
B112B-87
No communications possible with the steering
w heel module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
B112C-87
No communications possible with the interior
monitoring sensor module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
B1D17-87
No communications possible with the anti-theft
a larm signal horn with integrated battery.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0231-87
No communications possible with the rain
s ensor/light sensor.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
B1130-87
No communications possible with the light switch
u nit.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0214-00
No communications possible with the keyless
v ehicle module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0104-00
No communication possible with the distance
w arning system radar unit.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0199-00
No communication possible with the driver's side
f ront door module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0200-00
No communication possible with the passenger
s ide front door module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0252-00
No communication possible with the trailer
module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0128-00
No communication possible with the electric
REFER to: Communications Network (418-00 Module Communications
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=1449&proc-uid=G927143&gui...
2012-08-11
873831852.371.png 873831852.372.png 873831852.373.png 873831852.375.png 873831852.376.png 873831852.377.png 873831852.378.png 873831852.379.png 873831852.380.png 873831852.381.png 873831852.382.png 873831852.383.png 873831852.384.png 873831852.386.png 873831852.387.png 873831852.388.png 873831852.389.png 873831852.390.png 873831852.391.png 873831852.392.png 873831852.393.png 873831852.394.png 873831852.395.png 873831852.397.png 873831852.398.png 873831852.399.png 873831852.400.png 873831852.401.png 873831852.402.png 873831852.403.png 873831852.404.png 873831852.405.png 873831852.406.png 873831852.408.png 873831852.409.png 873831852.410.png 873831852.411.png 873831852.412.png 873831852.413.png 873831852.414.png 873831852.415.png 873831852.416.png 873831852.417.png 873831852.419.png 873831852.420.png 873831852.421.png 873831852.422.png 873831852.423.png 873831852.424.png 873831852.425.png 873831852.426.png 873831852.427.png 873831852.428.png 873831852.430.png 873831852.431.png 873831852.432.png 873831852.433.png 873831852.434.png 873831852.435.png 873831852.436.png 873831852.437.png 873831852.438.png 873831852.439.png 873831852.441.png 873831852.442.png 873831852.443.png 873831852.444.png 873831852.445.png 873831852.446.png 873831852.447.png 873831852.448.png 873831852.449.png 873831852.450.png 873831852.452.png 873831852.453.png 873831852.454.png 873831852.455.png 873831852.456.png 873831852.457.png 873831852.458.png 873831852.459.png 873831852.460.png 873831852.461.png 873831852.463.png 873831852.464.png 873831852.465.png 873831852.466.png 873831852.467.png 873831852.468.png 873831852.469.png 873831852.470.png 873831852.471.png 873831852.472.png 873831852.474.png 873831852.475.png 873831852.476.png 873831852.477.png 873831852.478.png 873831852.479.png 873831852.480.png 873831852.481.png 873831852.482.png 873831852.483.png 873831852.485.png 873831852.486.png 873831852.487.png 873831852.488.png 873831852.489.png 873831852.490.png 873831852.491.png 873831852.492.png 873831852.493.png 873831852.494.png 873831852.496.png 873831852.497.png 873831852.498.png 873831852.499.png 873831852.500.png 873831852.501.png 873831852.502.png 873831852.503.png 873831852.504.png 873831852.505.png 873831852.507.png 873831852.508.png 873831852.509.png 873831852.510.png 873831852.511.png 873831852.512.png 873831852.513.png 873831852.514.png 873831852.515.png 873831852.516.png 873831852.518.png 873831852.519.png 873831852.520.png 873831852.521.png 873831852.522.png 873831852.523.png 873831852.524.png 873831852.525.png 873831852.526.png 873831852.527.png 873831852.529.png 873831852.530.png 873831852.531.png 873831852.532.png 873831852.533.png 873831852.534.png 873831852.535.png 873831852.536.png 873831852.537.png 873831852.538.png 873831852.540.png 873831852.541.png 873831852.542.png 873831852.543.png 873831852.544.png 873831852.545.png 873831852.546.png 873831852.547.png 873831852.548.png 873831852.549.png 873831852.552.png 873831852.553.png 873831852.554.png 873831852.555.png 873831852.556.png 873831852.557.png 873831852.558.png 873831852.559.png 873831852.560.png 873831852.561.png 873831852.563.png 873831852.564.png 873831852.565.png 873831852.566.png 873831852.567.png 873831852.568.png 873831852.569.png 873831852.570.png 873831852.571.png 873831852.572.png 873831852.574.png 873831852.575.png 873831852.576.png 873831852.577.png 873831852.578.png 873831852.579.png 873831852.580.png 873831852.581.png 873831852.582.png 873831852.583.png 873831852.585.png 873831852.586.png 873831852.587.png
Strona 5 z 21
p arking brake module.
N etwork, Diagnosis and Testing).
U0122-00
No communication possible with the damper
c ontrol module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0101-00
No communication possible with the
t ransmission control unit.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0164-00
No communication possible with the electronic
t emperature control module.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0001-00
No communications possible via the HS CAN bus.REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
U0010-00
No communications possible via the MS CAN
b us.
REFER to: Communications Network (418-00 Module Communications
N etwork, Diagnosis and Testing).
Symptom chart
Symptom chart
Symptom
Possible Sources
Action
Generic electronic module (GEM) not communicating
with the diagnostic unit.
*
*
*
Fuse(s).
Circuit(s).
Generic electronic
module (GEM).
*
REFER to: Communications Network (418-00 Module Communications
Network, Diagnosis and Testing).
Voltage supply (term. 30) faulty.
*
*
*
Fuse(s).
Circuit(s).
Generic electronic
module (GEM).
*
GO to Pinpoint Test A.
Pinpoint test
PINPOINT TEST A : VOLTAGE SUPPLY (TERM. 30) FAULTY.
CAUTION: Before replacing the GEM in the event of a GEM malfunction, PERFORM a "hardware reset" after WORKING THROUGH the relevant DTC.
To do this, disconnect connector C1BP02-G from the GEM and reconnect it. CHECK the operation of the system. If the malfunction persists, make sure
that the latest release of the software is loaded in IDS and that the correct variant of the GEM is installed. CONFIGURE GEM again using IDS. If the fault
occurs again, RENEW THE GEM.
TEST CONDITIONS
DETAILS/RESULTS/ACTIONS
A1: CHECK FUSE F17
1
Ignition switch in position 0.
CHECK Fuse F17 (EJB).
2
Is the fuse OK?
Yes
GO to A2 .
No
RENEW fuse F17 (60 A). CHECK the operation of the system. If the fuse blows again, LOCATE and REPAIR
the short using the Wiring Diagrams.
A2: CHECK THE VOLTAGE AT FUSE F17
1
Connect Fuse F17 (EJB).
2
Does the meter display battery voltage?
Yes
Measure the voltage between fuse F17 (60 A) and ground.
GO to A3 .
No
REPAIR the voltage supply to fuse F17 with the aid of the Wiring Diagrams. CHECK the operation of the
system.
A3: CHECK FUSE F18
1
Is the fuse OK?
Yes
CHECK Fuse F18 (EJB).
GO to A4 .
No
RENEW fuse F18 (60 A). CHECK the operation of the system. If the fuse blows again, LOCATE and REPAIR
the short using the Wiring Diagrams.
A4: CHECK THE VOLTAGE AT FUSE F18
1
Connect Fuse F18 (EJB).
2
Does the meter display battery voltage?
Yes
Measure the voltage between fuse F18 (60 A) and ground.
GO to A5 .
No
REPAIR the voltage supply to fuse F18 with the aid of the Wiring Diagrams. CHECK the operation of the
system.
A5: CHECK THE VOLTAGE AT THE GEM
1
Disconnect Connector C1BP02-G from the GEM.
2
Measure the voltage between the GEM, connector C1BP02-G, pin 1, circuit SBB17A (RD), wiring harness
side and ground.
Does the meter display battery voltage?
Yes
GO to A6 .
No
LOCATE and REPAIR the break in circuit SBB17A (RD) between the GEM and fuse F17 with the aid of the
Wiring Diagrams. CHECK the operation of the system.
A6: CHECK THE VOLTAGE AT THE GEM
Measure the voltage between the GEM, connector C1BP02-G, pin 2, circuit SBB18A (YE), wiring harness
side and ground.
1
http://127.0.0.1:8888/wsm/js/procedure.do?variantId=1449&proc-uid=G927143&gui...
2012-08-11
873831852.588.png 873831852.589.png 873831852.590.png 873831852.591.png 873831852.592.png 873831852.593.png 873831852.594.png 873831852.596.png 873831852.597.png 873831852.598.png 873831852.599.png 873831852.600.png 873831852.601.png 873831852.602.png 873831852.603.png 873831852.604.png 873831852.605.png 873831852.607.png 873831852.608.png 873831852.609.png 873831852.610.png 873831852.611.png 873831852.612.png 873831852.613.png 873831852.614.png 873831852.615.png 873831852.616.png 873831852.618.png 873831852.619.png 873831852.620.png 873831852.621.png 873831852.622.png 873831852.623.png 873831852.624.png 873831852.625.png 873831852.626.png 873831852.627.png 873831852.629.png 873831852.630.png 873831852.631.png 873831852.632.png 873831852.633.png 873831852.634.png 873831852.635.png 873831852.636.png 873831852.637.png 873831852.638.png 873831852.640.png 873831852.641.png 873831852.642.png 873831852.643.png 873831852.644.png 873831852.645.png 873831852.646.png 873831852.647.png 873831852.648.png 873831852.649.png 873831852.651.png 873831852.652.png 873831852.653.png 873831852.654.png 873831852.655.png 873831852.656.png 873831852.657.png 873831852.658.png 873831852.659.png 873831852.660.png 873831852.663.png 873831852.664.png 873831852.665.png 873831852.666.png 873831852.667.png 873831852.668.png 873831852.669.png 873831852.670.png 873831852.671.png 873831852.672.png 873831852.674.png 873831852.675.png 873831852.676.png 873831852.677.png 873831852.678.png 873831852.679.png 873831852.680.png 873831852.681.png 873831852.682.png 873831852.683.png 873831852.685.png 873831852.686.png 873831852.687.png 873831852.688.png 873831852.689.png 873831852.690.png 873831852.691.png 873831852.692.png 873831852.693.png 873831852.694.png 873831852.696.png 873831852.697.png 873831852.698.png 873831852.699.png 873831852.700.png 873831852.701.png 873831852.702.png 873831852.703.png 873831852.704.png 873831852.705.png 873831852.707.png 873831852.708.png 873831852.709.png 873831852.710.png 873831852.711.png 873831852.712.png 873831852.713.png 873831852.714.png 873831852.715.png 873831852.716.png 873831852.718.png 873831852.719.png 873831852.720.png 873831852.721.png 873831852.722.png 873831852.723.png 873831852.724.png 873831852.725.png 873831852.726.png 873831852.727.png 873831852.729.png 873831852.730.png 873831852.731.png 873831852.732.png 873831852.733.png 873831852.734.png 873831852.735.png 873831852.736.png 873831852.737.png 873831852.738.png 873831852.740.png 873831852.741.png 873831852.742.png 873831852.743.png

Plik z chomika:

Inne pliki z tego folderu:

Inne foldery tego chomika:

Zgłoś jeśli naruszono regulamin