SUN ROOF SYSTEM.pdf

(267 KB) Pobierz
2005 Toyota RAV4
2005 ACCESSORIES & EQUIPMENT Sliding Roof System - RAV4
2005 ACCESSORIES & EQUIPMENT
Sliding Roof System - RAV4
LOCATION
910871680.005.png 910871680.008.png 910871680.009.png 910871680.011.png
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
2005 Toyota RAV4
2005 ACCESSORIES & EQUIPMENT Sliding Roof System - RAV4
Fig. 1: Identifying Component Location Of Sliding Roof System
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
910871680.003.png 910871680.004.png
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
2005 Toyota RAV4
2005 ACCESSORIES & EQUIPMENT Sliding Roof System - RAV4
INSPECTION
1.
CHECK SLIDING ROOF CONTROL SWITCH AND RELAY CIRCUIT
a.
Disconnect the connector from the switch and relay. Check the connector on the wire harness side
as shown in Fig. 2 below.
Fig. 2: Identifying Sliding Roof Control Switch Terminals
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
910871680.006.png 910871680.007.png
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
2005 Toyota RAV4
2005 ACCESSORIES & EQUIPMENT Sliding Roof System - RAV4
Fig. 3: Tester Connection Specified Condition Chart
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
NOTE:
*Exceptions: For 40 seconds after the ignition switch is turned from
ON to OFF (ACC) or until the driver or passenger door is opened after
the ignition switch is turned from ON to OFF (ACC).
If the result is not as specified, there may be a malfunction on the wire harness side or limit switch.
b.
Reconnect the connector to the switch and relay. Check the connector on the wire harness side as
shown in the Fig. 4 below.
Fig. 4: Tester Connection Specified Condition Chart
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
If the result is not as specified, replace the sliding roof control switch and relay.
2.
INSPECT SLIDING ROOF MOTOR CIRCUIT BREAKER OPERATION
a.
With the sliding roof in the fully open position, hold down the sliding roof switch in the "SLIDE
OPEN" position. Check if a circuit breaker operation noise is heard within 10 to 60 seconds.
910871680.010.png 910871680.012.png 910871680.013.png
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
2005 Toyota RAV4
2005 ACCESSORIES & EQUIPMENT Sliding Roof System - RAV4
Fig. 5: Inspecting Sliding Roof Motor Circuit Breaker Operation
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
b.
With the sliding roof in the fully open position, hold down the sliding roof switch in the "TILT UP"
position. Check if the sliding roof begins to close within 60 seconds.
If operation is not as specified, replace the motor.
910871680.001.png 910871680.002.png
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 

Plik z chomika:

Inne pliki z tego folderu:

Inne foldery tego chomika:

Zgłoś jeśli naruszono regulamin